Suzuki ATV Carborator question ?

  • Thread starter Thread starter semick_15
  • Start date Start date
S

semick_15

Guest
Here's a problem that I bet not even you can figure out... I own a 1987 Suzuki 250cc Quad-Runner ATV. For the entire summer it has ran perfectly. Then at the end of the summer season I took some exterior carb cleaner so that I wouldn't have so much dirt and grime on the outside of it. So to do this I had to take the carb off. I didn't open it up or adjust it in any way. When I put it back on it ran not as good. Then as the weather had got colder out, when i need to start it for th first time each day I have to choke it for 1-2 min and then it doesn't run that great. It will not idal and it seems like the throttle is sticking a little bit when I deaccelarate. Also sometimes when I deaccelerate it will idle very low and sometimes hick-up or stall. I've tryed adjusting hte idle on it but it's not different. When I rev it up it will run fine but it won't idle or start easly. I have to play with the choke sometimes. All the seals are good and everything was put back in the right way. The carb is good and clean on the inside. all the ports are clean and my fuel lines, fuel pump, and filer are clean. But once it's warmed up it will start with no problem. I am fed up with this and I can't figure it out. I have no book for it so I don't know the specs for setting the carb, but it should be in the right spot because I haven't moved it. If you can figure this out I would be amazed and very grateful too.

Thanks for the help!!!!
 
Back
Top