99 suzuki katana 600 exhaust issue startup problem.. any expert to help ?

  • Thread starter Thread starter j s
  • Start date Start date
J

j s

Guest
Hey Folks!
I've recently acquired a '99 Suzuki Katana 600, which I'm totally loving being on.. however, there's couple of things which do makes me a bit uncomfortable, and I can't help thinking of fixing them somehow..
just fyi.. I've recently got the Jets changed (replaced a new kit) with the fuel flowing richer than usual..
Now, for starters, I'm facing ignition / startup problems in the morning.. although it's cold here, but still it takes quite a while, and after starting the first time, the rpm gets lower and lower and ultimately the engine stops.. (even using choke)
Then comes the part where I have to throttle it a bit to start, and it gives out quite some smoke too..
Soon after it's up, I still get the engine cutting off on me at certain points, as if the exhaust is choked.. there's quite a lot of backfire pops from the exhaust.. and that continues for the whole time I ride it afterwards..

So, I hope you've got the scenario, and can guide me in the right direction.. :)

Thanks in advance..

J.
 
sounds like your too rich.Why did you change jets?Did you fit an after market race exhaust?If not put the standard jets back in.Upjetting a bike than cannot draw more air than standard won't make it run faster ,all that will happen is the extra fuel now being metered into the mix will flood the engine killing performance and costing more to run the bike.The back firing is the unburnt fuel being ignited by the hot exhaust.If you check your plugs they will almost certainly be black with soot,so if it were my bike I'd fit std jets ,clean the plugs and take it fof a blast to clean it out.
 
your timing is not adjustable and you dont have points. It does sound like way to rich. put your old jets back in,in the future dont fix what aint broke
 
Back
Top